气缸主要作用是通过压缩空气的开关流向实现伸缩和摆动等动作. (一).公司所用到的气缸主要有以下几种类型: 一. 无导向气缸1.圆缸 需传感器安装支架 2.方缸 3.紧凑型气缸2010-6-2 1 二. 有导向气缸 1.带滑块的气缸: a.DGSL 滑块 精确度高,封闭式滚珠导向,重复精度高, 两端采用弹性缓冲,并且不带金属挡块 b.SLF 滑块 扁平结构带高精度滚珠导轨和可调端位 c. SLF, SLS, SLT 滑块 窄型结构带 高精度滚珠导轨 d. SLT 滑台 高精度,耐重载的滚珠导轨和可调刚性端位. e. 滑动单元(双活塞) SPZ 双活塞杆, 2.带导杆的气缸a 微型导向驱动器 DFC 带滑动导轨. 直径 4, 6, 10 mm 行程 5 … 30 mm 输出力 7,5 … 47 N 2010-6-2 2 b 中型导向驱动器 DFM 导向气缸,内置导轨 C 高精度导杆气缸 DFP 导向气缸,抗扭转, 双活塞杆. d 紧凑型气缸 ADVUL 带防止活塞转动的导柱 e 导向驱动单元 SLE 直线驱动单元 可配置 圆缸加配件 3.双活塞杆的气缸 DPZ 带两根平行的活塞杆,位置感测,终端带弹性缓 冲环 三.其它气缸 1.直线摆动夹紧缸 CLR 夹紧系统,具有直线及摆动动作,90 度向右 2010-6-2 3 2.摆动气缸带可调液压缓冲器和能补偿间隙的齿轮系统. 摆动角度 0 ... 360 用于搬运和装配的系统产品. 3.平行气爪/旋转气爪自对中,内抓取或外抓取,182°摆角,位置感测 4.夹紧模块 2010-6-2 4 5.气囊式气缸 6.无杆气缸 7.膜片式气缸 8.多位置气缸 (二)常见的气缸附件 2010-6-2 5 (三) 气缸常见故障 . 由于安装与使用不当气缸也会产生故障. 故障 原因分析 排除方法 活塞杆安装偏心 重新安装调整,使活塞杆不受偏心和横 外 泄 活塞杆端漏气 润滑油供应不足 向负荷. 检查油雾器是否失灵. 漏 缸筒与缸盖间漏气 活塞密封圈磨损 缓冲调节处漏气 活塞杆轴承配合面有杂质 更换密封圈. 活塞杆有伤痕 清洗除去杂质,安装更换防尘罩. 更换活塞杆. 内 活塞密封圈损坏 更换密封 泄 润滑不良 检查油雾器是否失灵 漏 活塞两端串气 活塞被卡住,活塞配合面 重新安装调整,使活塞杆不受偏心和横 有缺陷. 向负荷. 杂质挤入密封面 除去杂质,采用净化压缩空气. 润滑不良 检查油雾器是否失灵 输出力不足 活塞或活塞杆卡住 重新安装调整,消除偏心横向负荷. 动作不平稳 供气流量不足 加大连接或管接头口径 有冷凝水杂质 注意用净化干燥压缩空气, 防止水凝结. 缓冲密封圈磨损 更换密封圈 缓冲效果不良 调节螺钉损坏 更换调节螺钉 汽缸速度太快 注意缓冲机构是否适合 有偏心横向负荷 消除偏心横向负荷 损伤 活塞杆损坏 活塞杆受冲击负荷 冲击不能加在活塞杆上 气缸的速度太快 设置缓冲装置 缸盖损坏 缓冲机构不起作用 在外部或回路中设置缓冲机构

SMC气缸型号：
CHDKGB50-10
CHDKGB50-100
CHDKGB50-15
CHDKGB50-15M
CHDKGB50-20
CHDKGB50-25
CHDKGB50-35
CHDKGB50-40
CHDKGB50-50
CHDKGB50-75
CHDKGB5050MXC62
CHDKGB63-100
CHDKGB63-25
CHDKGB63-30
CHDKGB63-35
CHDKGB63-35M
CHDKGB63-40
CHDKGB63-50
CHDKGB63-75
CHDKGB63-80M
CHDKGB80-100
CHDKGB80-100M
CHDKGB80-15M
CHDKGB80-150
CHDKGB80-25
CHDKGB80-50
CHDKGB80-75
CKZ3T50-90T
CKZT50-A015CB
CKZ3T63-105T
CKZT63-A045CS
CKZ1N50-135LT
CKZ1N50-135RT
CKZ2N50-120RT
CKZ2N50-135RT
CKZ3N50-45DT
CKZ3N50-90DP
CKZ3N63-45DP
CKZ3N63-90DT
CKZ-50A011
CKZN50-135LN
CKZN50-135RN
CKZT40-135T
CKZT40-30T
CKZT40-45T
CKZT40-60T
CKZT40-A015CS
CKZT40-A015LS
CKZT40-A015RS
CKZT40-A045CS
CKZT63-120T
CKZT63-A045CS
CKZT63-A045LS
CKZT63-A045RS
CKZT63TN-120T
CKA80-KRF0027-75Y-P5DWZ
CKA-K75
CKA-Y04
CKA-YA04
CKB40-17-102B
CKB40-18-207A
CKB40-18-207B
CKB-Y04
CKCV32-135B-RH
CKG1A40-100
CKG1A40-100Y
CKG1A40-100YA
CKG1A40-125
CKG1A40-125Y
CKG1A40-125YA
CKG1A40-50
CKG1A40-50Y
CKG1A40-50YA
CKG1A40-50YA-P
CKG1A40-50Y-P
CKG1A40-50YZ
CKG1A40-75Y
CKG1A40-75YA
CKG1A40-75YA-P
CKG1A40-75Y-P
CKG1A40-75Y-P5DWL
CKG1A40-75YZ
CKG1A50-100
CKG1A50-100Y
CKG1A50-100YA
CKG1A50-100YABD-L
CKG1A50-100YA-P
CKG1A50-100YBD-L
CKG1A50-100Y-P
CKG1A50-125-X276A
CKG1A50-125Y
CKG1A50-125YA
CKG1A50-125YABD-L
CKG1A50-125YAD
CKG1A50-125YA-P
CKG1A50-125YBD-L
CKG1A50-125YD
CKG1A50-125Y-P
CKG1A50-150
CKG1A50-150Y
CKG1A50-150YA
CKG1A50-150YABD-L
CKG1A50-150YBD-L
CKG1A50-40YA
CKG1A50-50
CKG1A50-50Y
CKG1A50-50YA
CKG1A50-50YA-X276A
CKG1A50-50YA-X276B
CKG1A50-50YABDL
CKG1A50-50YA-P
CKG1A50-50YBDL
CKG1A50-50Y-P
CKG1A50-50Y-X276A
CKG1A50-50Y-X276B
CKG1A50-75
CKG1A50-75Y
CKG1A50-75YA
CKG1A50-75YABDL
CKG1A50-75YA-P
CKG1A50-75YA-X738
CKG1A50-75YBDL
CKG1A50-75Y-P
CKG1A50-75Y-X1515
CKG1A50-75Y-X738
CKG1A50-75YZ
CKG1A63-100
CKG1A63-100-P
CKG1A63-100Y
CKG1A63-100YA
CKG1A63-100YABD-L
CKG1A63-100YA-P
CKG1A63-100YBD-L
CKG1A63-100Y-P
CKG1A63-125
CKG1A63-125B
CKG1A63-125Y
CKG1A63-125YA
CKG1A63-125YABD-L
CKG1A63-125YAD
CKG1A63-125YA-P
CKG1A63-125YBD-L
CKG1A63-125YD
CKG1A63-125Y-P
CKG1A63-150Y
CKG1A63-150YA
CKG1A63-150YABD-L
CKG1A63-150YA-L
CKG1A63-150YA-P
CKG1A63-150YBD-L
CKG1A63-150Y-L
CKG1A63-150Y-P
CKG1A63-150Z
CKG1A63-200Y
CKG1A63-200Y-P
CKG1A63-30
CKG1A63-300Y-P
CKG1A63-50
CKG1A63-50Y
CKG1A63-50YA
CKG1A63-50YABDL
CKG1A63-50YA-P
CKG1A63-50YBDL
CKG1A63-50Y-P
CKG1A63-75
CKG1A63-75Y
CKG1A63-75YA
CKG1A63-75YABDL
CKG1A63-75YA-P
CKG1A63-75YBDL
CKG1A63-75Y-P
CKG1A63-75Y-P
CKG1A63-KRF0028-125YBDL
CKG1A63-KRF0028-75YBD
CKG1B40-50
CKG1B40-50Y
CKG1B40-50YA
CKG1B50-100
CKG1B50-100I
CKG1B50-100Y
CKG1B50-100YA
CKG1B50-100YA-X276A
CKG1B50-100YAL
CKG1B50-100YL
CKG1B50-100Y-X276A
CKG1B50-125Y
CKG1B50-125YA
CKG1B50-125YAL
CKG1B50-125YL
CKG1B50-150
CKG1B50-150Y
CKG1B50-150YA
CKG1B50-25Y
CKG1B50-25YA
CKG1B50-50
CKG1B50-50-P
CKG1B50-50-X1515
CKG1B50-50Y
CKG1B50-50YA
CKG1B50-75Y
CKG1B50-75YA
CKG1B50-75YA-X276A
CKG1B50-75YAL
CKG1B50-75YL
CKG1B50-75Y-X276A
CKG1B63-100
CKG1B63-100Y
CKG1B63-100YA
CKG1B63-100YA-P
CKG1B63-100YZ
CKG1B63-125
CKG1B63-125I
CKG1B63-125Y
CKG1B63-125YA
CKG1B63-150Y
CKG1B63-150YA
CKG1B63-50
CKG1B63-50Y
CKG1B63-50YA
CKG1B63-50Z
CKG1B63-75
CKG1B63-75Y
CKG1B63-75YA
CKG1P63-150YA-P
CKG1P63-150Y-P
CKG40-R050
CKG40-R075
CKG40-R100
CKGA100-125Y
CKGA100-150YL
CKGA100-150Y-P
CKGA32-100Y-X1046
CKGA32-125Y-X1046
CKGA32-75Y-X1046
CKGA32-B6859-100Y
CKGA32-B6859-125Y
CKGA32-B6859-150Y
CKGA32-B6859-50Y
CKGA32-B6859-75Y
CKGA80-100Y
CKGA80-125Y
CKGA80-150YL
CKGA80-50Y
CKP1A63-100Y
CKP1A63-100YA
CKP1A63-125
CKP1A63-125Y
CKP1A63-125YA
CKP1A63-125YA-P74
CKP1A63-125Y-P74
CKP1A63-150
CKP1A63-150Y-P74-85G-X906
CKP1A63-150Y
CKP1A63-150YA
CKP1A63-200Y
CKP1A63-200YA
CKP1A63-50Y-P74-85G-X1442
CKP1A63-50Y
CKP1A63-50YA
CKP1A63-75Y
CKP1A63-75YA
CKP1A63-75YA-P74
CKP1A63-75Y-P74
CKP1A63-75Y-P74-85G-X404
CKP1A63-B5052-50Y
CKP1A63-S0971-50
CKP1A63-S0971-75
CKP1AM63-200Y
CKPA80-150Y
CKQ40-25-DCH244DH
CKQ40-25-DCH245DH
CKQ40-25-DCH248DH
CKQ40-25-DCH249DH
CKQ40-P6136-25
CKQ40-P6138-25
CKQ40-P6140-25
CKQ40-P6142-25
CKQ40-P9616-25
CKQ40-W0377-25
CKQ40-W0378-25
CKQ40-W3950-25
CKQ40-W3951-25
CKQ50-15-DCJ9682J
CKQ50-DCG2437GA15
CKQ50-DCG2438GA15
CKQ50-DCG5907GL12
CKQ50-DCG5918GCA15
CKQ50-DCG7225G-16
CKQ50-DCG7226G-16
CKQ50-DCG5918GCA15
CKQ50-P5743-30
CKQ50-P7118-30
CKQ50-W3247-15
CKQ50-W3247A15
CKQ50-W3247B15
CKQ50-W8040A15
CKQ50-W8041A15
CKQGDB50-199RALS
CKQN50-25-155WA
CKQN50-25-158WA
CKQSC50-125RC
CKQSF50-125RDS
CHDKGB80150XB11
CHDMB20-Z0860
CHDMB20-200
CHDMB20-25
CHDMB20-40
CHDMB20-75
CHDMB20Z0860155
CHDMB25-50
CHDMB25-75
CHDMB32-100
CHDMB32-80
CHDMB40-250
CHDMB40K
CHDMC20-75
CHDMC32-80
CHDMC40-25
CHDMF20-40
CHDMF25-40
CHDMF32-350
CHDMF32-50
CHDMF32K
CHDMG20-205
CHDMG32-75
CHDML20-400
CHDML25-200
CHDQB100-100
CHDQB100-100D
CHDQB100-25D
CHDQB100-50D
CHDQB100-75D
CHDQB100R184910
CHDQB20-0128624

现货供应日本SMC系列产品，如需详细了解请点击：SMC全系列